Hey guys, need some opinions on my current intake setup, lost power at high end and top speed compare to previous setup (previous- drop in then this Works system with original air routing)

not here to compare drop in/open pod or anything to this 'closed pod' setup .. just need opinion as to why Im losing power (120-140kmh so much slower to reach now)



piping size 2.5-3inch, properly sealed, few parts joint together so 'surface' not that smooth, but wont be too much issue right..

so based from the look, not getting enough air at high speed? or too much air not enough fuel? I doubt

non-cps neo tho.. Thanks.

Now got nothing to read AFR

My physics definately failed ahha .. If posible wil tweak this diy intake a liltle, else will source for open pod then diy heatshield

hi guys.. anyone know where to get cps steering wheel (except from proton spare part shop?) and new one around how much?

Planning to get 1 for my non CPS neo can be used right ... Thanks..

Edit:forgot zth..

This post has been edited by Ericz: Feb 18 2014, 09:36 PM

Hi guys, I'm looking for Neo CPS stock steering, so trying my luck here, see if anyone wanna sell his

Also if anyone know which fuse is for the fog lamp? cant find on the cover label, the closest thing labeled 'fog' is a relay. My fog lamp not working ady ~~

thx

Hi max yeah, but dont see anythin labeled as 'fog lamp' except the F.Fog relay.. so maybe thats the thing to change?

both fog lamp not working now, bulb ok wire ok~ hvnt check any future

thanks

so u remember actually Iv already replaced the connector back with the original one, tested and working.. thn one day I turn it on again only to find that its not working anymore thn removed the bumper and re-check the wiring.. ok je

hey guys, got a question:

except for the pressure switch on the door, what else can cause the 'door open' indicator to go on/off?

My problem is when drivin along, the 'Door Open' indicator will flicker if the road is not completely smooth, so far I think is the pressure switch fault.. cus if I knock on the door panel from inside, can see the indicator flicker also..

or anyone know how the pressure switch work? cus if I remove the screw, the indicator will not light up, its like the screw is needed to complete the circuit ground?

normal spare part shop can get replacement?

mine last few months ady problem but not so bad, if I poke it a few times with my finger thn ok balik .. now most of the time the indicator just flicker

yesterday only I open the switch, very simple inside.. just a few copper plate and a spring, also for me, the driver and the pesanger side switch is different
just need to go figure out how the button work..

very annoying the indicator keep flickering, worry nanti something else like the led or relay bakar plak

hi , yep already off it, else will be like disco inside (seriusly) the problem is the indicator on the dash~ keep flashing make me think sooner or later the led or sumthin else wil burn due to the constantly changin on/off state

yep, last time yes, that how I discover my problem, wen car parked at the side of the road, suddenly the alarm goes off, while on while off..

now use key to lock first

anyway the switch is really simple, hope just the plate dirty so contact no good, try to clean later and see how..
btw just now drop by a spare part shop, since its neo, they dun stock the part.. (as usual ) they say can order for me, will jsut take one day.. but then I 4gt to ask for price

for me it worked.. so my issue is really the 'pressure switch'. the plate inside got 'dirty' (sum stuff buildin on the surface) over time, thus creating resistance between the 2 contact surface, and making the connection weak..

after driving around for a day, the issue didnt come back.. thats for my case anyway, for gen2 im not sure, maybe realy is the thing thats supposed to press the switch down misaligned

hey guys, anyone using LED bulb on the 'small' front light? I've changed mine to a 5smd led and noticed it flickering (like strobe light) randomly while the engine is running, with engine off it is ok tho.

What could be the problem? Any idea?

1.) the led is cheap type RM10 something
2.) I hv led bulb for interior light and boot light, they have no problem
3.) I hvnt try swaping to the back (number plate light)

Thx, will try to check.. but its both sides and while engine not runin its perfectly fine tho

Hi Max if heavy rain.. mine hvin the same problem.. checked mine and its due to the rubber attached to a 'thing' (behind the speaker) that came off.. that 'thing' is to direct the water going into the door panel out kot

btw jus curious.. my retrofitted headlamp, can still open up and change bek to the stock halogen projector?

wonderin if theres anykind of whatsapp group for SNeo

my Neo gave me a new problem to solve ytday loud metal "clunk" noise when turnin steering

when driving, the noise is very minimal or no noise at all, but loud when car is parked.
since yesterday evening, few days ago heavy rain, drove thru a few deep puddles at around 40-60km/h, that might be the cause?

actually there's another problem since months ago.. sometimes when driving slow (and normally is when car still cold after stopped for some time) can hear a soft 'klurk klurk klurk' noise when going slow, going str8 or turn the noise also there, searched for similar thread .. but can't help much .. when send for servicing the mech cant detect also, maybe cus it's still not tat serious so visually they cant tel which part is wearing out? when the mech test drove he say no problem also

Just a lil update, checked and it was the steering rack bushes

RM250 for the steering bush (2pcs) include labour and RM40 to 'pump bush' (send to others to change the bush frm steering rack)

Hey guys, just wondering, if you are thinking of replacing your NEO with a car that is around RM80k, which car wld it be?

Condition to meet:
- Used/New, no matter
- Prefer Hatchback -> B segment SUV -> B seg sedan (NOT Myvi, Godcar Vios, Almera)
- Handle as good as NEO
- Moderate power ~ 100hp++(Quite subjective hmm)
- As good looking as NEO (Subjective a bit haha)
- Practicality - no matter
- Resale value - no matter, maybe cheap to maintain~

So what would it be?
First I can think of is Fiesta, pay bit more for ecoboost?
Rio is very sexy, but not really that 'powerful' I heard


Just random question anyway