Hi Guys,clarification for Proton 5 Years warranty:

To be eligible for the warranty;

-Carry out all scheduled maintenance service at PROTON authorised service centres.
-Follow your service booklet recommendations
-Use only PROTON genuine parts and recommended engine oil
-Do not modify your vehicle in any way that affects performance of parts
-Do no operate your car under strenuous circumstances, such as in races or rallies.
For other Proton Models (2 years Manufacture Warranty + 3 years Extended warranty)
For Exora and Saga (3 years Manufacture Warranty + 2 years Extended warranty)

The following parts/ components are covered under this Extended Warranty:
1. ENGINE 
Cylinder Block including:- 
Pistons, Piston Rings, Connecting-rods & bearings, Crankshaft, Crankshaft main
bearing, Gudgeon pins & bearings, Thrust bearing. 
Cylinder Head including:- 
Camshaft, Camshaft bearings, Cam followers, Timing-gears, Timing chains &
guides, Rocker assembly including: Hydraulic rocker, Rocker arm, Rocker shafts,
Rocker bushings, Cylinder head valves, collects, valves lifters, Valve springs,
Valve seals, Valve spring retainers, Valve seats, Valve guides, Pushrods, Head
gasket (s), Oil-pump (including oil-pump housing),  Oils seals, Inlet & Exhaust
manifolds, Flywheel ring gears, 
Excluding: - Plugs, High-tension leads, All cables  including wiring harness, All
belts including Timing belt(s). All hoses & tubes,  clamps & chips, Engine
mountings, Oil-pan, V-belt Tensioner device including bearing, Core plugs,
Breathers & Filters.

2.  TRANSMISSION 
a) Manual-Internal gears & shafts, baulk rings and bearings, Syncro hubs, Selector
fork, seals & bushes, Reverse light switch, sensors & solenoids, Odometer drivegears, Oils seals & gaskets.
Excluding: - All cables & rubber bushes, Gearbox mounting, Clutch-plate,
Pressure Plate, Release bearing. 
b) Automative - Torque-converter, Drive-plate, Gears, Shafts & Bushes, Oil-pump,
Seals, Governors, Servo, Faxiplate, Solenoids & switches, Parking pawl
assembly, Odometer drive-gears, gear linkages, Valve body, Clutches & brake
bands.
Excluding: - All cables including wiring-harness, burnt or worn out clutches &
brake bands, all pipes & hoses, Mountings, all rubber bushes, filters.

3.  DRIVE TRAIN
Crown-wheel & pinion, bearing & oil seals, Differential gears, Driveshafts &
Constant-velocity joints, propeller shaft/ halfshaft, Wheel-bearings, Axlebearings, Locking rings, Universal-joints, 4 wheel- drive unit, Free-wheeling hub.
Excluding: - Gaiters, Clips, Rubber boots, Rubber-couplings, Mountings. 6

4. COOLING SYSTEM
Radiator, Oil-cooler, Water-pump including pulley,  Viscous-0coupling,
Thermostat, Thermostat housing & gasket, Thermostatically controlled-fan
(including motor), temperature sender units.
Excluding: - V-belt, hoses, clamps & clips, coolant.

5. FUEL SYSTEM
Actuator, Air mass sensor, Fuel-pump, Fuel Injection Pump & injectors,
Carburettor, Automatic choke unit, Diesel injection-pump & injectors, Diesel liftpump, Fuel-tank sending unit.
Excluding: - Adjustments & tuning e.g. Fuel lines,  Filters, Gaskets, All cables,
clips, hoses & Relays.

6. FRONT & REAR SUSPENSION
Coil springs, Leaf springs, Ball & swivel joints, Panhard rods, Upper & lower
control arms, Bushes, Stabilizer-bars, Stabilizer-bars links & bushings.
Excluding: - Wheel alignments & balancing adjustments, Noises, Squeaks &
Rattles e.g. Shock absorbers, Strut inserts, All pipes & hoses, Wheels & Tyres.

7. STEERING SYSTEM
Steering-box unit, rack & pinion, Steering column, Power steering pump, Pitman
arm, Idler arm, Tie-rod ends, Drag link, Universal joints, high pressure hoses.
Excluding: - All belts, hoses, pipes, Gaiters, clips, Rubber boots.

8. BRAKE SYSTEM
Brake servo, non-return valve, Master & Wheel cylinders, Restrictor valve, Disc
brake calliper & Seals, Pedal assembly & linkages,  ABS electronic control
processor, ABS speed sensor, Pressure differential valve.
Excluding: - Noises from the brake system e.g. Pads, shoes, All hoses, pipes,
springs, Disc rotors, Brake drums, Front hubs, Parking brake system (including
linkages), All cables.

9. ELECTRICAL SYSTEM
Starter motor unit including solenoid, Alternator unit, Voltage regulator,
Distributor, Coil unit, Washer pump, Power window unit, Power mirror motor,
Headlamp adjuster motor, Stop lamp switch, Wiper system.
Excluding:- Batteries, light bulbs / Units, Wiper blades/rubbers, Distributor cap,
All cables, Relays, Horn, Headlamp adjustment mechanism, Remote control,
Alarm system. 7

10. ENHANCED ELETRICAL 
Engine control unit including Automatic Cruise Control, Transmission control unit.
Note: - Any damage resulting from defective “wiring harness” (prior to the failure
of the control unit) and/or mishandling of the unit(s) is not covered by the
warranty.

11. AIR CONDITIONER 
Compressor, Compressor clutch, Condenser, Evaporator / Cooling coil,
Expansion valve. Suction throttling valve, Automatic Climate Control Unit, Blower
motor, relays.
Excluding: - Bearings, Scals, Pulleys, All belts &  hoses, All cables, Switches,
Receiver Dryer, Oil, Refrigerant.

12. BODY EXTERIOR
Bonnet release mechanism, Glove compartment latch / lock.
Excluding: - Safety Restrain System (SRS) and all cables.

13. BODY EXTERIOR
Petrol cap release mechanism, Boot & Tailgate release mechanism, Tailgate
lock.
Excluding: - All cables & any damages caused by forced entry.

14. CASINGS
Damage caused to casing and other mechanical & electrical parts as a direct
result of the failure of a covered compartment. 8

PROVIDED THAT All major mechanical & electrical components that  are warranted
shall only be replaced wholly if repair and replacement of internal parts of the component
is not possible or exceeds the total cost of the whole component.
COMPONENTS, PARTS AND EXPENSES NOT COVERED
1.  All Components & Parts not covered as above

2.  Paintwork, bodywork, water ingress and corrosion, glass, lenses, trim, bright
work, door lock cylinders and airbags. 

3.  Wheels, wheel balancing, tyres, exhaust system and catalytic converter. 

4.  Engine tuning, cleaning of fuel lines, filters, nozzles, carburettors and pumps,
drive belts that are not encased, impact or external damage, decarbonisation and
failures caused by the build up of carbon deposits (including burnt valves) 

5.  All wiper blades and rubbers, hoses, pipes and unions. 

6.  Mountings (including engine mountings), tapings, supports, fixings, and fastening
devices that has been incorrectly repaired or replaced or is subject to routine
servicing adjustments. 

7.  Batteries, wires, terminals, reconnecting of disturbed electrical connections,
lamps, bulbs, fuses, audio and in-car entertainment equipment and aerials and
car telephones. 

8.  Failure of clutch and brake materials due to wear, adjustments, alignments and
any items associated with manufacturer's recommended routine servicing, or
failures due to the lack of oils or coolant through neglect. 

9.  Seals and gaskets that are subject to replacement or refitment as part of the
normal service schedule. 

10.  Fuel, chemical, materials, additives, hydraulic fluids, oils or grease except where
required in direct connection with a repair to a covered part. 

11.  The cost of normal servicing, service items and other items which can be
expected to wear as part of their function.