owner sifu sendiri service own car. you should learn how to service your own car.

jerking second gear: service body throttle at joining air filter box.
jerking when slow down: service grid teaching by proton service workshop computer connecting.

charge : RM20 to RM30 service body throttle.
charge : RM65 to RM75 computer connecting service

---

Added on December 21, 2012, 7:36 pmdavid ........ how much the LED light one piece ?

This post has been edited by acerB314: Dec 21 2012, 07:36 PM

7 buck for 4 pcs is over cheapest.

if you talking changing gear jerking of AMT, couldn't done, kecuali you change twin clutch.
if you done like service body throttle, you cut the vacuum hose from oil tank then separate air filter box,
if you done like engine dirty because the dust and rain water go into engine, you adjust bonnet center screw nut little bit for close lapat.

after done... you check and see your engine no dust and no water go into TDC sensor and Body Throttle.

careful when wash car done like water go into engine. very sensitive same like volkswagoon engine Polo, Golf car.....

your car front gril very argury, why not you change new one..?

hello... anyone want buy 3.5 jack hand Phone? new. I no use after bought mobile phone.


Attached thumbnail(s)

hiyaa this matter kacang putih. do u clean oil sensor?

u remember car savvy AMT have two electronic boards. injection board and AMT board.
savvy MT have one board. injection board only.
AMT board control auto gear. if any shock circuit AMT board cut off and indicator auto lamp on and cut off speed meter.
new car design no more use cable wire speed meter.
car onwards use electronic control speed meter.
you won't believes me, is up to you.


Attached thumbnail(s)

aiyoo psy,bukan robortic laa, my car 6 years never change sensor and replace AMT parts, see my drawing that sensor clean it then seal the wire + - use pvc tape or silicon
Workshop will ask u replace part macam ini dia boleh cari makan n proton also,
Upto u pilih who right.

no. no .no not this one. this bukan sensor. this wire connecter.

sensor located at bottom of spark coil.

no no no not the exhaust sensor CO2. this sensor is osigen sensor.

near oil tank upper. you look at engine behind got one sensor. i call it oil sensor,
you try snap photo, so every know sensor located.

no..no..no.. speed sensor located at gearbox bottom front wheel left side....with electronic wire...
you full turning steering, you can see speed sensor at bottom gearbox...

you please try snap one photo at the back of engine... i call it oil sensor...

you see
engine top have water mark.

i think you same like my car also,
today check by forman said my engine pulley bearing kong 2pcs and need to change :-
1. belt tension bearing (Topper)
2. belt tension with gear bearing (Lower)
3. belt
4. screw nut holding belt tension bearing

for 4 items need to change. if not engine loud noise and RPM going lower when idling time.


this 4 items you choice original from renault or locate made malaysia
BEARING:-
1. original bearingvery expensive but won't jam when wear off told by forman.
2. locate made malaysia bearing name RAIDO wear off and jam told by forman.

RAIDO your familiar this company..?

Oh
Thanks.
Yes is Gaido
How the quality.?

do you check your clutch...?
if the clutch wear off won't release gear plate.
if the clutch cover wear off, is very hard changing gear

ask your brother give more detail:-
idling time : RPM.....? than switch on air con : RPM....?

this bearing wear off. and loud noise.
belt tension bearing upper of power steering pump.
and another one at lower of compressor.
RPM lower when idling time.


Attached thumbnail(s)

this is renault bearing.


Attached thumbnail(s)

that y i said:-
not AMT gear box problem and not Sensor problem.
u spend RM20,000 the problem still there.

plotong closed there eyes and shooting in the dark. kena tak kena tak apa because savvy owner pay for it.

the problem is from plotong designer... savvy car body rain goto engine and shock.

david after you replaced 2pcs new tension bearing, do you spray anti rust grease for bearing long life run..?
hardware shop have sell one bottle RM25.00
made from USA
lubricant grease and anti rusty.

this air con switch will be crack soon.
you just replaced knob only.
RM55.00 one unit.
spare part shop have selling, if you go workshop will be change whole set.

This post has been edited by acerB314: Mar 30 2013, 02:29 PM


Attached thumbnail(s)